Filter
Top Products
PAGE 14 — BP-25H CE GASOLINE VIBRATOR — OPERATION MANUAL — REV. #4 (12/19/07)
V-Belt Check
A worn or damaged V-belt can adversely affect the
performance of the vibrator.
1. Unscrew the bolts (7) securing the belt guard to the unit.
2. Inspect the V-belt for defects or signs of wear.
3. If the V-belt is defective or worn, replace the V-belt as
outlined in the maintenance section of this manual.
4. A properly tensioned V-belt (Figure 23) should deflect
approximately 5 to 10 mm when 5-10 pounds of force is
applied centrally between the pulleys.
BP-25H CE GASOLINE VIBRATOR — INSPECTION (ENGINE)
Figure 5. Engine Oil Dipstick (Removal)
Figure 6. Engine Oil Dipstick (Oil Level)
Engine Oil Check
1. To check the engine oil level, place the backpack frame
on secure level ground with the engine stopped.
2. Remove the filler dipstick from the engine oil filler hole
(Figure 5) and wipe clean.
Before Starting
Before starting and operating the BP-25H CE Gasoline
Vibrator, perform the following:
■
Read safety instructions at the beginning of the manual.
■
Clean the engine, removing dirt and dust, particularly
the engine cooling air inlet, carburetor and air cleaner.
■
Check the air filter for dirt and dust. If air filter is dirty,
replace air filter with a new one as required.
■
Check carburetor for external dirt and dust. Clean with
dry compressed air.
■
Check fastening nuts and bolts for tightness.
■
Check the engine oil level.
■
Check the fuel level.
■
Check the tension and condition of the V-belt.
3. Insert and remove the dipstick without screwing it into
the filler neck. Check the oil level shown on the dipstick.
4. If the oil level is low (Figure 6), fill to the edge of the oil
filler hole with the recommended oil type (Table 3).
Maximum oil capacity is 0.26 quarts (0.25 liters).
Fuel Check
1. Remove the gasoline cap located on top of fuel tank.
2. Visually inspect to see if fuel level is low. If fuel is low,
replenish with unleaded fuel.
3. When refueling, be sure to use a strainer for filtration. DO
NOT top-off fuel. Wipe up any spilled fuel.
epyTliO.3elbaT
nosaeS erutarepmeT epyTliO
remmuS rehgiHroC°52 03-W01EAS
llaF/gnirpS C°01~C°52 02/03-W01EAS
retniW rewoLroC°0 01-W01EAS
UPPER LIMIT
LOWER LIMIT
Gasoline is extremely flammable, and its
vapors can cause an explosion if ignited.
DO NOT start the engine near spilled fuel
or combustible fluids.
DO NOT fill the fuel tank while the engine is running or hot.
DO NOT overfill tank, since spilled fuel could ignite if it
comes into contact with hot engine parts or sparks from
the ignition system. Store fuel in approved containers, in
well-ventilated areas and away from sparks and flames.
When refueling vibrator, ALWAYS remove backpack from
operator.
DANGER - EXPLOSIVE FUEL HAZARD